Product ID:EZ WELD ORANGE CPVC SOLVENT CEMENT
MSDS Date:02/20/1986
FSC:8040
NIIN:00N038293
MSDS Number: BQXJL

PCI INDUSTRIES INC

1661 OLD DIXIE HIGHWAY
RIVIERA BEACH, FL 33404
US

Emergency Phone: 305-844-0241

Info Phone: 305-844-0241

Preparer: HARRY AUSTIN

Cage: FO174

PCI INDUSTRIES INC

9845 RIVIERA BEACH, FL 33419 US

Telephone: (407) 844-0241

Cage: FO174

OTHERWISE, DILUTE WITH WATER AND USING INERT

RTECS: 9999999ZZ

OF AS SOLID WASTE ACCORDING TO FEDERAL, STATE AND

RTECS: 9999999ZZ

TETRAHYDROFURAN (SARA III)

CAS: 109-99-9

RTECS: LU5950000

Fraction By Weight: 45%

OSHA PEL 200 PPM;250 STEL

ACGIH TLV: 200 PPM;250 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

2-BUTANONE;(METHYL ETHYL KETONE) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 30%

OSHA PEL 200 PPM;300 STEL

ACGIH TLV: 200 PPM;300 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

CYCLOHEXANONE (SARA III)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: 10%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:LD50:(ORAL RA)1620 MG/KG.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:POTENTIAL LOCAL AND SYSTEMIC
EFFECTS DUE TO SINGLE OR SHORT TERM OVEREXPOSURE TO THE EYES AND
SKIN THROUGH INHALATION OR INGESTION. EYE:CAUSES IRRITATION,
REDNESS, TEARING, BLURRED VISION. SKIN: CAN CAUSE SLIGHT TO
MODERATE IRRITATIONAND DEFATTING (DRYNESS). INHAL:CAN CAUSE NASAL &
RESPIRATORY (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IRRITATION, NAUSEA, DIZZINESS,
VOMITING AND DIARRHEA. CHRONIC:EYE:MARKED IRRITATION (BURN),
POSSIBLE TRANSIENT CORNEAL OR CONJUCNTIVAL INJURY. SKIN:SEVERE
IRRIT & DEFAT. CAN CAUSE RASH. INHAL :CAN CAUSE RESP IRRIT, VOMIT &
INCOORDINATION. INGEST:CAUSES NAUSEA, VOMITING, HEADACHE,
DIZZINESS, STUPOR, DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES.
CALL MD. SKIN:REMOVE CONTAMINATED CLOTHING PRIOR TO FLUSHING
W/WATER. LAUNDER CONTAMINATED CLOTHING BEFORE RE-USE. WASH SKIN
THOROUGHLY W/MIL D SOAP & WATER. INHAL:SEEK FRESH AIR. IF PERS
AFFECTED, MOVE TO FRESH AIR. IF BRTHG DFCLT, GIVE O*2. IF BRTHG
STOPPED GIVE ARTF RESP. KEEP WARM, QUIET & GET MD. INGEST:DO NOT
INDUCE VOMIT. (SUPP DATA)

Flash Point:6F,-14C
Lower Limits:2%
Upper Limits:12%
Extinguishing Media:ALCOHOL RESISTANT FOAM, CARBON DIOXIDE OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG GROUND OR MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS,
OTHER FLAMES, SPARKS, HEATERS, SMOKING, (SUPP DATA)

Spill Release Procedures:EXTING & DO NOT TURN ON ANY IGNIT SOURCE UNTIL
AREA IS DETERMINED TO BE FREE FROM EXPLO/FIRE HAZS. SMALL
SPILL:ABSORB W/EARTH, SAND OR SIMILAR INERT MATL & DISP OF W/SOLID
WASTE ACCORDING TO FED, STAT E & LOC REGS. FLUSH SPILL AREA
W/WATER.(SUPP DATA)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
AVOID BREATHING VAPOR. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
KEEP CONTAINER CLOSED.
Other Precautions:USE WITH ADEQUATE VENTILATION. CONTAINERS OF MATERIAL
MAY BE HAZARDOUS WHEN EMPTIED SINCE EMPTIED CONTAINERS RETAIN
PRODUCT RESIDUES (VAP, LIQ &/OR SOLID). ALL HAZARD PRECAUTIONS
GIVEN IN THIS DATA SH EET MUST BE OBSERVED.

Respiratory Protection:IF TLV OF PRODUCT OR ANY COMPONENT OF IT IS
EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED
IN ABSENCE OF PROPER ENVIRON CNTRL. OSHA REGULATIONS ALSO PERMIT
OTHER NIOSH/MSHA APPROVE D RESPIRATORS UNDER SPECIFIED CNDTNS.
Ventilation:IF PROD USED IN CONFINED AREA, PROVIDE SUFFICIENT
MECHANICAL (GENERAL &/OR LOCAL EXSHT VENT. EXPLO PROOF EQUIP
ADVISED.
Protective Gloves:RUB, BUTYL OR OTHER IMPERVIOUS GLOVES.
Eye Protection:CHEM WORK GOGG/FULL LENGTH FSHLD .
Other Protective Equipment:EYE BATH, SAFETY SHOWER, RUBBER SAFETY
BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ:ELEC MOTORS, STATIC DISCHARGE, OR OTHER IGNIT SOURCES AT
LOCATIONS DISTANT FROM MATL HANDLING POINT. FIRST AID PROC:IF PERS
CONSCIOUS, DILUTE BY GIVING 2 GLASSES OF WATER. CALL MD. KEEP PERS
WARM/QUIET. LRG SPILL:ERECT TEMPORARY (OR PERMANENT) DIKE TO CNTN
SPILL. COLLECT & DESTROY BY LIQ INCIN. (ING 4)

Boiling Pt:B.P. Text:150F,66C
Vapor Pres:114 @ 63F
Vapor Density:2.5
Spec Gravity:0.9 (H*2O=1)
Evaporation Rate & Reference:4 (N-BUTYL ACETATE=1)
Solubility in Water:55%
Appearance and Odor:ORANGE COLORED LIQUID WITH STRONG SOLVENT ODOR
Percent Volatiles by Volume:85%

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS:CARBON
DIOXIDE, CARBON MONOXIDE, AND VARIOUS HYDROCARBONS.

Waste Disposal Methods:COMPLY WITH FEDERAL, STATE AND LOCAL
REGULATIONS. IF PERMITS & REGULATIONS ALLOW, MAY BE INCINERATED,
ALLOWED TO EVAPORATE OR SOLIDIFIED WITH INERT MATERIAL AND DISPOSED
OF.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.